Currently reading: Renault to repurpose EV batteries into home energy storage systems
Renault has teamed up with Powervault to give used electric vehicle batteries a ‘second life’ as home energy storage units

Renault will repurpose used electric vehicle batteries with home energy company Powervault, into a home storage system akin to Tesla’s Powerwall. 

Powervault claims that using former electric vehicle batteries in this way could recede the cost to consumers of a Powervault ‘smart battery’ by 30%. This will help the company on its mission to reach the tipping point of home energy storage ownership in the UK, as the second life packs will start at around £3000; down from around £4300.

An initial production run of 50 units made from repurposed Renault electric vehicle batteries will be made, and supplied to selected homes fitted with solar panels who are customers of M&S Energy, as well as Greenwich schools and some social housing residences. Renault and Powervault aim to gauge the repurposed batteries’ performance compared with conventionally-sourced ones, as well as attain customer feedback. 

Customers with solar panels are being selected, as the packs allow them to store energy collected from the panels, as well as charging at off-peak grid times, allowing the cheaper energy to be used later, when the cost may be higher to use electricity straight from the grid.

Renault claims that the added usage on top of the batteries’ life inside an electric vehicle can more than double their entire life cycle; after eight to ten years of use in EVs, the batteries can be used for around a further ten years in a Powervault. 

Speaking of the recycling process, a Powervault spokesman said: "The batteries are taken back by Renault dealers and removed from cars. Then the car packs are taken apart and the 48 li-ion battery ‘modules’ within it are tested and graded. Those over 70% of their original state of health are then repacked into smaller portable battery packs by Powervault."

"Each pack is 8 modules which gives 2.5KWh of battery capacity. One, two or three of those packs can then be fitted into a Powervault unit in a customer home. Any modules which are below 70% state of health may be found other ‘second life’ homes or recycled responsibly."

Read more:

EV and combustion-engined car ownership costs to equalise by 2025, says Renault

Dynamic EV charger that works at 60mph could end range anxiety

Insight: why demand from China could spur growth of electric car sales

2018 Nissan Leaf – striking design previewed in first image

Hot Renault Zoe e-sport gets 460bhp

Join the debate

Add a comment…
Phil R 5 June 2017


I think I saw through @bobbyllew that a company were trying this with Nissan Leaf batteries, but got into problems when the expected degradation rate was too low and so all the cell's remained in cars rather than getting re-used. It would be interesting to know if individual cell's can be tested to see their condition, or if it's the pack as a whole that gets tested.
bol 5 June 2017

Storing solar is a key benefit

People who produce solar energy from their roofs during the day, but use most energy in the evening will be able to use their own "free" energy rather than pass it back to the grid. Scale this up to industrial levels in places like Africa or California and we'll be energy secure.
Ruperts Trooper 5 June 2017

Clever financial ploy

Sounds like a great scheme to get out of the cost and complexity of recycling these batteries with their toxic components - pass it on to some-one else.
xxxx 5 June 2017

Ploy? Just common sense

I suggest you re-read it, it says “a further ten years” and then they’re be re-cycled, only this time up to 10 years later. No ploy just doubling their potential life span with the same end of life process.