Owners of Single Motor Extended Range and Twin Motor Performance versions of the Volvo EX30 have been instructed not to leave their cars unattended while charging indoors or in covered areas, due to a battery fire risk.
Volvo recently identified an issue with battery cells overheating in the long-range versions of the EV, which use a 69kWh pack comprising nickel-managanese-cobalt modules.
Cells that overheat can cause a fire that spreads to the rest of the pack, potentially igniting the rest of the car.
The new advice comes from discussions between Volvo and the Driver and Vehicle Standards Agency (DVSA), after the brand advised owners of these EX30s not to charge to more than 70% to mitigate the risk of fire.
A DVSA notice said: "Currently the investigation is still ongoing with the final service solution being developed."
Owners have been advised to limit the maximum charge level of their cars' batteries to 70% because, Volvo told Autocar, “the risk of this rare issue happening is significantly reduced below this level of charge”.
A charge limit can be applied through the charge settings menu in the EX30’s touchscreen infotainment system.
If cells overheat, a warning is displayed on the touchscreen stating: “Danger! Battery overheating. Stop safely now and exit car.”
In a statement sent to Autocar, Volvo said the number of such incidents reported so far amounts to 0.02% of all the 33,777 EX30s with that battery built over that timeframe – equating to seven cars.
The company added that there have been no reports of personal injuries related to the fault and that it plans to bring in the affected cars for remedial work.
“We plan to roll out a recall as soon as possible to fix the cars in question,” Volvo said. “In the meantime, we are contacting all affected owners to ask them to limit their cars’ maximum charge level to 70%. We will contact them again as soon as a fix is available.
"Other models are not affected by this notice and not all variants of EX30 are affected.”
The fault doesn't affect the entry-level version of the EX30, the Single Motor, which employs a different battery entirely – a 49kWh pack using the lithium-iron-phosphate chemistry.
Join the debate
Add your comment
So it doesnt matter if the car is outside, then goes up in smoke?
And even outdoors charging to 70% gives an effective battery capacity of less than 49kWh.
That said perhaps there is a degree of over caution being applied given the very low incident rate (and ithis could mean no more than a warning light, or total vehicle loss in the case of fire).
if this was a Rolls Royce, Bentley or any other low volume EV the problem would simply not have occurred,
Wow, who'd have thought things could get worse for Volvo. My advice to EX30 owners sitting in their car for 7 hours overnight would be to leave the door open... just in case you need a quick exit!
Someone doesn't understand how it works. They've already put plans in place to try to stop that figure growing, these additional ones go further still.
But at the end of day I suppose it's ok as long as you're the one without a burnt down house or car.
Wonder if there are any Smart #1 or #3s that are affected by these, seeing as they're the same car